Ford Sierra



Ford Sierra
1.2. Car identification
2. Maintenance service
3. The general data
4. Engines
5. Coupling
6. Transmissions
7. A kardannyj shaft and the back bridge
8. A steering
9. Suspension brackets
10. Brake system
11. A body
- 12. An electric equipment
   12.1. Technical characteristics
   12.2. The relay and safety locks
   12.3. Removal and generator installation
   12.4. Dismantling and generator assemblage
   12.5. Tension adjustment клинового a belt
   12.6. A starter
   12.7. A windscreen screen wiper, knot of indexes and a headlight
   12.8. Removal and installation of a combination of devices
   12.9. Adjustment of light of headlights
    12.10. Heating and ventilation system
    12.11. Electroschemes



12. An electric equipment

12.1. Technical characteristics
THE GENERAL DATA

THE ACCUMULATOR

The accumulator by pressure 12 In and capacity of 35 Ach (270 А/50 RC), 43 Ach (360 A/60 RC) or 54 Ach (500 A/75 RC) is used. The negative pole of the accumulator is connected to weight of the car.

THE GENERATOR

The generator with the built in electronic regulator is applied.
Mark: Bosch, Lucas or Motorola.
Rated voltage: 14 Century
The maximum current strength: 35, 45 or 55 And.

Generators Bosch

Type
К1 (R) 14V 35A 20
К1 (R) 14V 45A 20
К1 (R) 14V 55A 20
№ under the catalogue
0120489172
0120489087
0120489099
Current strength () at number of turns (rpm)
10 at 130023
23 at 200035
35 at 6000
10 at 125030
30 at 205040
40 at 355045
45 at 6000
10 at 120036
36 at 200040
40 at 235055
55 at 6000
Resistance of a winding:
  – статора (Ohm)
0,26 – 0,286
0,18 – 0,198
0,14 – 0,154
  – A rotor (Ohm)
4,0 – 4,4
4,0 – 4,4
4,0 – 4,4

Generators Lucas

Type
AND 115/35
AND 133/45
AND 133/55
Current strength () at 6000 rpm
35
45
55
The maximum steady number of turns (rpm)
15 000
15 000
15 000
Resistance of a winding статора (Ohm)
0,133 0,05
0,295 0,01
(статор "delta")
0,098 0,01
(статор "star")
0,203 0,01
  Resistance of a winding of a rotor (Ohm)
3,2 0,16
3,2 0,16
3,2 0,16
The minimum length of brushes (mm)
5,0
5,0
5,0
  Adjustable pressure ()
13,7 – 14,6
13,7 – 14,6
13,7 – 14,6

Generators Motorola

Type
SD 35
SD 45
SD 55
Current strength () at 6000 rpm
35
45
55
The maximum steady number of turns (rpm)
15 000
15 000
15 000
Resistance of a winding статора (Ohm)
0,35 0,05
0,28 0,014
0,24 0,012
  Resistance of a winding of a rotor (Ohm)
4 0,2
4 0,2
4 0,2
The minimum length of brushes (mm)
4
4
4
  Adjustable pressure ()
13,7 – 14,6
13,7 – 14,6
13,7 – 14,6

Klinovoj belt


Mark: Motorcraft 83 HF 6C 301 AA, Motorcraft 83 HF 8A 615 AA or 83 HF 6B 301 BA.

Tension (checked up on a cold belt the special adaptation):
Belt new:

  – The single: 400 – 500 Н;
  – The double: 440 – 620 Н;
The belt which was in the use, (after at least 10 mines of work):
  – The single: 300 – 400 Н;
  – The double: 300 – 400 Н

Deflection: 10 mm by pressing by a thumb in the middle большего a belt piece.

STARTER

Starters Bosch

Type
EF (R) 12V 0,8 kw
GF (R) 12V 1,1 PS
№ under the catalogue
0 001 211 228
0 001 311 113
Idling check
50 And at 11,5 In and 6000 rpm
70 And at 11,5 In and 7500 rpm
Short circuit check
9 In at 300 – 390 А8 In at 280 – 350 And
7,4 In at 480 – 560 А6,5 In at 410 – 490 And
The moment (Nanometer)
12,5 – 15,0
15,0 – 16,0
The minimum pressure of inclusion ()
7,5
8,0
Diameter of a collector (mm):
  – The nominal
36,0
36,0
  – The minimum
33,5
33,5
Force of a clip of brushes ()
11,5 – 13,5
18 – 21
The minimum length of brushes (mm)
13
13
Axial backlash of a rotor (mm)
0,1 – 0,3
0,1 – 0,3

The control size of the electromagnetic switch (regulated):

  – Starter Bosch 0 001 211 228: 16,00,15 mm;
  – Starter Bosch 0 001 311 113: 28,50,2 mm

Starter Lucas

Type: 5 M of 90 or 8 M 90.
The minimum width of a collector: 2,05 mm.
The minimum length of brushes: 8,0 mm.
Force of a clip of brushes: 8 Н.
Axial backlash of a rotor: 0,25 mm

Starters Cajavec and Nippondenso

Mark
Cajavec
Nippondenso
Nippondenso
Capacity (kw)
0,88
0,6
0,8
The minimum diameter of a collector (mm)
32,8
28,0
28,0
The minimum length of brushes (mm)
10,0
10,0
10,0
  Force of a clip of brushes ()
4 0,2
4 0,2
4 0,2
The minimum length of brushes (mm)
16
15
12
 Axial backlash of a rotor (mm)
0,3
0,6
0,6

WINDSCREEN SCREEN WIPER


The screen wiper with two speeds with possibility of faltering work is applied.

ILLUMINATION

Headlights

Mark: Bosch or Hella.

Bulbs

Quantity
Use
Capacity (Вт)
2
Headlights distant and passing light Н4
55/60
2
Headlights of headlight Н3 (Ghia)
55
2
Forward antifog headlights Н3 (Ghia)
55
2
Back dimensional fires and braking (berlin)
21/5
8 or 10
Braking lanterns (комби), turn indexes, a back antifog lantern and a backing lantern
21
4
Forward dimensional fires and licence plate illumination
5