Ford Sierra



Ford Sierra
1.2. Car identification
2. Maintenance service
- 3. The general data
    3.1. Cars with petrol engines
   - 3.2. Cars with diesel engines
      - 3.2.1. Changes in a design of the car with 1988 to 1993
         3.2.1.1. The engine 2,3 дм3
          3.2.1.2. The engine 1,8 дм3
          3.2.1.3. Fuel system
          3.2.1.4. The repair which is not demanding removal of the engine
         3.2.1.5. Removal and engine installation
         3.2.1.6. Engine dismantling
         3.2.1.7. Check of details
         3.2.1.8. Check of backlashes of a cranked shaft and rods
         3.2.1.9. Engine assemblage
         3.2.1.10. Greasing system
         3.2.1.11. Cooling system
         3.2.1.12. Coupling
         3.2.1.13. A mechanical five-speed transmission of type МТ 75
         3.2.1.14. A power shaft and the back bridge
         3.2.1.15. Steering system
         3.2.1.16. A forward suspension bracket
         3.2.1.17. Brake system
         3.2.1.18. The electric equipment
         3.2.1.19. The general data
4. Engines
5. Coupling
6. Transmissions
7. A kardannyj shaft and the back bridge
8. A steering
9. Suspension brackets
10. Brake system
11. A body
12. An electric equipment


3.2.1.18. The electric equipment
THE GENERAL DATA

The generator

Cars Ford Sierra 1,8 Turbo D are equipped with generator Bosch N1 70 And or Lucas A 127/70.

Klinovoj belt

Mark and type: Dayco. A deflection: 4 mm under thumb pressing.

Starter

Cars Ford Sierra 1,8 Turbo D are equipped with starter Bosch JF with the following data.

Capacity: 2,2 kw.

Number of brushes: 4. The minimum length of brushes: 32,8 mm.

Axial backlash of a rotor: 0,3 mm.

SAFETY LOCKS AND THE RELAY

Since September, 1990 connection of safety locks and the relay in the electric equipment of the car is changed.

Identification of safety locks

№ a safety lock
Current ()
Protected contour
1
15
The left headlight of a headlight
2
15
The right headlight of a headlight
3
7,5
The left headlight of a passing light
4
7,5
The right headlight of a passing light, the proof-reader of installation of headlights
5
5
Dimensional fires left: forward and back
6
5
Dimensional fires right: forward and back
7
15
Illumination of a combination of devices and the forward panel
8
15
Radio receiver
9
15
Screen wipers of headlights
10
7,5
Salon illumination, hours, the central lock, electric adjustment of an external rear-view mirror
11
15
The fuel pump
12
10
Emergency fires, the alarm system, the central lock
13
20
Heating of forward seats, прикуриватель
14
10
Sound signal
15
15
Engines of screen wipers and the pump of a washer of glass
16
20
Heating of back glass and наружнего rear-view mirrors
17
15
Forward antifog headlights
18
10
The fan engine
19
7,5
Back antifog headlights (the version for Sweden and Norway)
20
10
Indexes of turns, backing fires
21
7,5
Braking fires
22
4
A food of indexes of control means
23
20
The fuel pump
24
30
Lifts of lateral glasses

The prevention

The main box of safety locks and the relay is in a back part of a motor compartment on the left side.


Additional safety locks are located in a box under the forward panel on the right side (between an average part of the forward panel and a ware box) and it:

 – A safety lock № 28 (25 And – white) – the additional fan of a radiator;
 – A safety lock № 29 (30 And – green) – the air-conditioning device;
 – A safety lock № 30 (20 And – yellow) – antiblocking system (ABS);
 – A safety lock № 31 (30 And – green) – the pump of I system ABS;
 – A safety lock № 33 (25 And – white) – the basic fan of a radiator;
 – A safety lock № 34 (30 And – green) – the pump of II system ABS;
 – A safety lock № 35 (1 And – black) – module EES IV;
 – A safety lock № 36 (10 And – red) – the operating knot EGR (рециркуляция exhaust gases).

Besides, on separate wires of power supplies there are following safety locks:

 – The main safety lock (nearby 55) – on a wire () the accumulator;
 – The onboard computer (1) – under an instrument guard;
 – Fuel system of injection (20) – about the relay;
 – Electric opening of a back door of a body (1) – about the ignition switch;
 – A radio receiver (2 And; 3,15 And or 6,3) – on a wire of power supplies or behind a radio receiver.

The relay

And relays can be in the main box of safety locks following relays:

 – № And: engine works;
 – № In: additional fires for movement in the afternoon (only Sweden and Norway) or back antifog headlights;
 – № With: a sound signal;
 – № D: engine control systems;
 – № Е: back antifog headlights;
 – № F: passing light headlights;
 – № G: heating of forward seats;
 – № H: forward antifog headlights;
 – № I: the ignition switch;
 – № II: the core of fires for movement in the afternoon (only Sweden and Norway);
 – № III: screen wipers of headlights;
 – № IV: heating of back glass;
 – № V: программатора a windscreen screen wiper;
 – № VI: the switch of illumination of salon;
 – № VII: antiblocking system ABS;
 – № VIII: the mechanism kick-down an automatic transmission;
 – № IX: программатора a screen wiper of back glass;
 – № X: headlight headlights;
 – № XI: engine control systems;
 – № XII: safe start of the engine (starter blocking) in cars with an automatic transmission.

In a motor compartment behind a box it is located by the relay of initial warming up of the engine (management свеч накаливания).

Other information, concerning a technical characteristics, adjustment and electric equipment repair, is resulted in section 12.